Suzukillc

November 5, 2007

United States

Suzuki Motor USA, LLC

THE REAR REFLEX REFLECTOR ON AFFECTED GS500 MOTORCYCLES AND THE REAR AND SIDE REFLEX REFLECTORS ON AFFECTED GZ250 MOTORCYCLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

September 25, 2007

United States

Suzuki Motor USA, LLC

ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.

August 15, 2007

United States

Suzuki Motor USA, LLC

ON CERTAIN MOTORCYCLES, EACH TIME THE IGNITION SWITCH IS TURNED OFF, THE ENGINE CONTROL MODULE (ECM) PRE-SETS THE POSITION OF THE IDLE SPEED CONTROL (ISC) VALVE FOR SUBSEQUENT ENGINE STARTING BY OPENING THE VALVE COMPLETELY AND THEN CLOSING IT TO A START-UP POSITION.

July 24, 2007

United States

Suzuki Motor USA, LLC

ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT TONGUE WILL NOT LATCH INTO THE BUCKLE AND, IN RARE CASES, EVEN THE LOCKED TONGUE WILL POP OUT BY LOW STRETCHING FORCE. IF THE BUCKLE DOES NOT LATCH COMPLETELY, THE BUCKLE COULD RELEASE WITHOUT PRESSING THE RELEASE BUTTON.

July 15, 2007

United States

Suzuki Motor USA, LLC

ON CERTAIN VEHICLES EQUIPPED WITH 5-SPEED MANUAL TRANSMISSIONS, DUE TO IMPROPER SHAPE OF THE CLIP, THE RETAINING CLIP THAT KEEPS THE GEAR SHIFT CABLE ATTACHED TO THE GEAR SHIFT LEVER CAN CONTACT THE GEAR SHIFT LEVER HOUSING IF EXCESSIVE LATERAL FORCE IS APPLIED WHEN SHIFTING TO FIRST GEAR.

June 14, 2007

United States

Suzuki Motor USA, LLC

CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING.

April 4, 2007

United States

Suzuki Motor USA, LLC

ON CERTAIN MOTORCYCLES, THE FUEL HOSE THAT CONNECTS THE TWO METAL FUEL DELIVERY PIPES MOUNTED ON THE THROTTLE BODY MAY HAVE BEEN CLAMPED AT A LOCATION ON THE PIPES THAT IS NOT COMPLETELY ROUND, WHICH COULD ALLOW FUEL LEAKAGE TO OCCUR.

January 30, 2006

United States

Suzuki Motor USA, LLC

ON CERTAIN MOTORCYCLES, STRESS AROUND THE RIGHT FRONT FUEL TANK MOUNTING POINT CAN CAUSE HAIRLINE FATIGUE CRACKS TO FORM. THIS CAN RESULT IN A FUEL LEAK.

January 18, 2006

United States

Suzuki Motor USA, LLC

ON CERTAIN CALIFORNIA-SPECIFICATION MODEL MOTORCYCLES, REPEATED STRESS FROM VIBRATION CAN CAUSE A CRACK TO FORM IN THE AREA WHERE THE LIQUID/VAPOR SEPARATOR BRACKET IS WELDED INSIDE THE FUEL TANK. THIS CAN ALLOW FUEL LEAKAGE TO OCCUR.

December 21, 2005

United States

Suzuki Motor USA, LLC

ON CERTAIN MOTORCYCLES, THE IGNITION SWITCH WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED AT THE TIME OF PRODUCTION. IF THE WIRING HARNESS IS NOT ROUTED PROPERLY, IT CAN RUB AGAINST THE CLUTCH CABLE/THROTTLE CABLE.

December 1, 2005

United States

Suzuki Motor USA, LLC

ON CERTAIN PASSENGER VEHICLES, THE LEFT SIDE OF THE RETAINER REAR DRIVE SHAFT MAY CRACK AND THE GEARS MAY GET STUCK DUE TO OIL LEAKAGE BY THE RETAINER.

November 3, 2005

United States

Suzuki Motor USA, LLC

ON CERTAIN PASSENGER VEHICLES, THE POWER STEERING PUMP PULLEY MAY SEPARATE FROM THE POWER STEERING PUMP DUE TO INADEQUATE WALL THICKNESS OF THE PULLEY.

November 1, 2005

United States

Suzuki Motor USA, LLC

ON CERTAIN SCOOTERS, THE FUEL PUMP RETAINING RING MAY HAVE BEEN IMPROPERLY INSTALLED RESULTING IN IMPROPER SEATING OF THE FUEL PUMP RETAINING RING ON THE FUEL TANK DUE TO MISALIGNMENT OF THE THREADS.

October 5, 2005

United States

Suzuki Motor USA, LLC

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.

August 29, 2005

United States

Suzuki Motor USA, LLC

ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MAY BE UNSTABLE CONTACT BETWEEN THE IGNITION SWITCH CONTACTS. THIS CAN CAUSE ARCING IN THE IGNITION SWITCH.

January 28, 2005

United States

Suzuki Motor USA, LLC

ON CERTAIN PASSENGER VEHICLES, THE BRAKE LIGHT SWITCH MAY BECOME MISADJUSTED IF AN UPWARD/REARWARD FORCE IS APPLIED TO THE BRAKE PEDAL. IF THIS SHOULD OCCUR, THE BRAKE LIGHT SWITCH WILL NOT FUNCTION PROPERLY, CAUSING THE BRAKE LIGHTS, INCLUDING THE HIGH MOUNTED STOP LAMP, TO REMAIN ILLUMINATED CONTINUOUSLY WITHOUT…

August 30, 2004

United States

Suzuki Motor USA, LLC

ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.

August 13, 2004

United States

Suzuki Motor USA, LLC

IN CERTAIN PASSENGER VEHICLES, A FAULT IN THE ADAPTIVE FUEL CONTROL LOGIC CAN CAUSE SOME VEHICLES TO USE AIR/FUEL RATIOS DURING DECELERATION THAT ARE LEAN ENOUGH TO CAUSE ENGINE STALLING.

July 19, 2004

United States

Suzuki Motor USA, LLC

THIS CAMPAIGN INVOLVES CERTAIN MARAUDER MODEL MOTORCYCLES EQUIPPED WITH CALIFORNIA EVAPORATIVE EMISSIONS EQUIPMENT. WHEN A MOTORCYCLE IS PARKED AFTER CITY DRIVING IN HEAVY TRAFFIC, UNDER SOME CONDITIONS, ELEVATED PRESSURE IN THE FUEL TANK VENT LINE CAN CAUSE BACK PRESSURE IN THROUGH THE SURGE CONTROL VALVE.

July 2, 2004

United States

Suzuki Motor USA, LLC

ON CERTAIN MOTORCYCLES THERE IS A POSSIBILITY OF FUEL LEAKING FROM THE FUEL GAUGE GASKET DUE TO MISALIGNMENT OF THE GASKET AT THE TIME OF ASSEMBLY.