Jayco

September 21, 2010

United States

Jayco, Inc.

JAYCO IS RECALLING CERTAIN MODEL YEAR 2004 LEGACY AND MODEL YEAR 2005 DESIGNER FIFTH WHEEL TRAILERS EQUIPPED WITH DIMPLEX ELECTRAFLAME, SYMPHONY, OR OPTIFLAME BRANDED ELECTRIC FIREPLACES, STOVES, AND FIREPLACE INSERTS. THE PLUG IN REMOTE CONTROL RECEIVER FOR THE FIREPLACE CAN OVERHEAT.

September 9, 2010

United States

Jayco, Inc.

JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 JAY FEATHER SELECT TRAVEL TRAILERS, SERIES X213 MANUFACTURED FROM MAY 17, 2010 THROUGH AUGUST 16, 2010 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS.

July 26, 2010

United States

Jayco, Inc.

JAYCO IS RECALLING CERTAIN MODEL YEAR 2010 JAYCO SELECT CAMPING TRAILERS MANUFACTURED FROM NOVEMBER 11, 2009 THROUGH APRIL 6, 2010. THE AXLE IS LOCATED TOO FAR FORWARD ALLOWING THE TIRES TO MAKE CONTACT WITH THE WHEEL WELL, WHICH MAY CAUSE DAMAGE TO THE TIRE AND/OR THE WHEEL WELL.

February 18, 2010

United States

Jayco, Inc.

JAYCO IS RECALLING CERTAIN MODEL YEAR 2010 INSIGNIA MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS MANUFACTURED BETWEEN OCTOBER 14, 2009 AND JANUARY 15, 2010 WITH KONGSBERG POWER PRODUCTS SYSTEMS ADJUSTABLE BRAKE PEDALS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED…

January 26, 2010

United States

Jayco, Inc.

JAYCO IS RECALLING CERTAIN MODEL YEAR 2009-2010 EAGLE AND MODEL YEAR 2010 DESIGNER FIFTH WHEEL TRAVEL TRAILERS. IN THE PRESENCE OF MOISTURE, A REMOTE ACTIVATION MODULE FOR THE LEVELING JACK MAY ACTIVATE AUTONOMOUSLY WITHOUT THE USE OF THE REMOTE CONTROL.

July 23, 2009

United States

Jayco, Inc.

JAYCO IS RECALLING 273 MODEL YEAR 2002-2004 LEGACY FIFTH WHEEL MOTORHOMES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS…

June 16, 2009

United States

Jayco, Inc.

JAYCO IS RECALLING 647 MY 2009 JAY FEATHER EXP AND EX-PORT TRAVEL TRAILERS. THE SCREWS USED TO ATTACH THE BUNK DOOR CABLES TO THE BUNK DOORS MAY BE OF INSUFFICIENT LENGTH, WHICH COULD RESULT IN THE CABLE BECOMING DETACHED FROM THE DOOR WHILE THE TRAVEL TRAILER IS PARKED AND SET UP WITH THE BUNK DOORS OPEN.

March 31, 2009

United States

Jayco, Inc.

JAYCO IS RECALLING 46 MY 2009 LEGACY SERIES 37RLSA AND 36RLMS FIFTH WHEEL TRAILERS. THERE MAY BE A MISSING GROUND WIRE BETWEEN THE TRAILER FRAME AND THE 12-VOLT BUS BAR.

October 15, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 410 MY 2008 JAY FLIGHT G2 SERIES 32BHDS TRAVEL TRAILERS. SOME NEUTRAL 120 VOLT WIRES MAY NOT BE PROPERLY INSTALLED UNDER THE NEUTRAL BUSS BAR SET SCREW WHICH MAY CAUSE THE WIRES TO BECOME LOOSE.

September 11, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 28 MY 2009 LEGACY FIFTH WHEEL TRAVEL TRAILERS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.

August 19, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 222 MY 2009 EAGLE SL TRAVEL TRAILERS. THE UPPER REAR PLASTIC CAP CAN BECOME DETACHED FROM THE REAR WALL DUE TO IMPROPER CLEANING OF MATING SURFACE TO ALLOW PROPER ADHESION.

August 14, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 265 MY 2007-2008 JAY FEATHER EXP TRAVEL TRAILERS. A P-CLAMP WAS NOT INSTALLED DURING PRODUCTION THAT WAS INTENDED TO PREVENT THE RUBBER LIQUID PROPANE (LP) LINE FROM CONTACTING THE SLIDE-OUT MECHANISM.

July 3, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 156 MY 2009 RECON, EAGLE, AND DESIGNER FIFTH WHEEL TRAVEL TRAILERS. AN ELECTRICAL SHORT CAN OCCUR IF THE METAL TERMINAL RUBBER CRIMP CAP WAS NOT INSTALLED CORRECTLY.

June 3, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 74 MY 1999-2001 DESIGNER FIFTH WHEEL MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

May 7, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 1,673 MY 2005-2008 SENECA MOTOR HOMES. AN ELECTRICAL SHORT CAN OCCUR IF THE BATTERY CABLES WERE NOT TUCKED INTO THE COMPARTMENT IN A MANNER THAT DOES NOT ALLOW THE CABLES TO BE PINCHED BETWEEN THE BATTERY SLIDE TRAY AND THE COMPARTMENT DOOR.

May 6, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 1,265 MY 2005-2008 SENECA '35GS' AND MY 2007-2008 GREYHAWK '33DS' AND '32SS' MOTOR HOMES. THE CONDUIT CLAMP ON THE COPPER LIQUID PROPANE (LP) TUBE FEEDING THE SLIDE-0UT IS INCORRECTLY PLACED WHICH MAY ALLOW THE COPPER TUBE TO BEND AND POSSIBLY LEAK WITH THE MOVEMENT OF THE SLIDE-OUT.

May 5, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 22 MY 2008 JAY FEATHER EX-PORT '17C' TRAVEL TRAILERS EQUIPPED WITH OPTIONAL HYDRAULIC BRAKES. SOME OPTIONAL HYDRAULIC BRAKE HOSES WERE ROUTED UNDER THE AXLE.

March 5, 2008

United States

Jayco, Inc.

JAYCO IS RECALLING 106 MY 2008 DESIGNER FIFTH WHEEL TRAILERS FAILING TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.

April 27, 2007

United States

Jayco, Inc.

CERTAIN FIFTH WHEEL TRAVEL TRAILERS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.

March 20, 2007

United States

Jayco, Inc.

CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.