Holidayramblercorp

February 1, 1994

United States

HOLIDAY RAMBLER CORP.

IMPROPER TORQUE OF THE RETAINING BOLTS AND NUTS OF THE STEERING COLUMN SLIP SHAFT, WHICH PROVIDES THE CONNECTING LINK BETWEEN THE UPPER STEERING COLUMN AND THE STEERING GEAR BOX, MAY CAUSE THE STEERING COLUMN SLIP SHAFT TO SEPARATE AT EITHER THE UPPER OR LOWER CONNECTION OF THE SHAFT.

July 21, 1993

United States

HOLIDAY RAMBLER CORP.

THE TWO REARWARD FRONT SUSPENSION FRAME MOUNTING BRACKETS CAN FRACTURE.

May 3, 1993

United States

HOLIDAY RAMBLER CORP.

THE LPG IRON MANIFOLD SYSTEM WAS NOT BONDED TO THE CHASSIS GROUND. THIS CAN CREATE THE POTENTIAL FOR ELECTRICAL ARCING BETWEEN THE CHASSIS FRAME AND THE LPG IRON MANIFOLD SYSTEM.

December 17, 1992

United States

HOLIDAY RAMBLER CORP.

THE DRIVER AND PASSENGER FRONT OUTBOARD OCCUPANT SEAT HAVE BEEN DESIGNED WITH THE SAFETY BELT ANCHORAGE ON THE SEAT STRUCTURE. IT IS POSSIBLE, IN A VEHICLE CRASH, THAT THE SEAT STRUCTURE WOULD FAIL TO WITHSTAND THE FORCES WITHIN THE LIMITS SET FORTH IN FMVSS 207 AND FMVSS 210.

August 14, 1992

United States

HOLIDAY RAMBLER CORP.

A LEAK OF EITHER GASOLINE OR PROPANE CAN OCCUR IN COMPONENTS OF THE DUAL FUEL SYSTEM. THIS CONDITION IS PRIMARILY THE RESULT OF THE CONFIGURATION AND LOCATION OF COMPONENTS IN AREAS WHERE HIGH TEMPERATURES ARE BEING GENERATED BY THE ENGINE AND EXHAUST SYSTEMS.

November 20, 1990

United States

HOLIDAY RAMBLER CORP.

TURBULENCE CAUSED BY AERODYNAMIC QUALITES OF THE MOTORHOMES AT HIGHWAY SPEED CAN CAUSE THE AWNING TO UNROLL AND BREAK FREE FROM ITS MOUNTING SECUREMENT.

October 19, 1990

United States

HOLIDAY RAMBLER CORP.

THE SUSPENSION COIL SPRING BOX MOUNTING BRACKETS, WHICH ARE FASTENED TO THE MAIN CHASSIS FRAME, MAY FAIL.

August 27, 1990

United States

HOLIDAY RAMBLER CORP.

INCORRECT SIZE EAR TYPE CLAMPS WERE USED TO SECURE NYLON GASOLINE LINES TO BARBED CONNECTOR FITTINGS.

March 12, 1990

United States

HOLIDAY RAMBLER CORP.

IMPROPER TORQUING OF STEERING WHEEL COULD CAUSE THE STEERING COLUMN STEEL SHAFT TO WEAR ON THE WHEEL ALUMINUM HUB.

April 5, 1989

United States

HOLIDAY RAMBLER CORP.

CLOSE PROXIMITY OF CERTAIN HOSES TO HIGH HEAT EMITTED FROM THE CATALYTIC CONVERTER WOULD CAUSE THE HOSE TO DETERIORATE.

March 20, 1989

United States

HOLIDAY RAMBLER CORP.

RUBBER GASOLINE HOSE USED TO ACCOMMODATE RELOCATION OF THE FUEL TANK IS SUBJECT TO DETERIORATION OVER TIME.

September 26, 1988

United States

HOLIDAY RAMBLER CORP.

LEAK IN LP GAS SERVICE LINE CAUSED BY LINE CONTACTING REAR SUSPENSION SYSTEM WHICH RESULTS IN LINE RUPTURE.

January 22, 1988

United States

HOLIDAY RAMBLER CORP.

UNDER HEAVY DEMAND ON THE ENGINE AND TRANSMISSION, THE TRANSMISSION COOLER LINE TEMPERATURE CAN EXCEED THE TEMPERATURE RATING OF BOTH THE PLASTIC CONDUIT AND INSULATION FOR THE BATTERY CABLE.

December 29, 1987

United States

HOLIDAY RAMBLER CORP.

ROUTING OF THE HEADLIGHT AND CLEARANCE LIGHT CIRCUITS THROUGH A SINGLE 20 AMP FUSE AND/OR BREAKER WHICH IS NOT ADQUATE FOR THE LOAD CREATED BY BOTH CIRCUITS.

August 14, 1987

United States

HOLIDAY RAMBLER CORP.

ROUTING OF AIR SUPPLY LINES CLOSE TO THE EXHAUST MANIFOLD PIPE SUBJECT THE LINES TO DEFORMATION AND POSSIBLE RUPTURE FROM THE RADIANT HEAT OF THE PIPE.

June 9, 1987

United States

HOLIDAY RAMBLER CORP.

WIRING HARNESSES LOCATED TO THE REAR OF THE ENGINE COMPARTMENT COULD CHAFE AND SHORT CIRCUIT.

November 13, 1986

United States

HOLIDAY RAMBLER CORP.

LP SERVICE LINE COULD RUPTURE, DUE TO HYDROSTATIC PRESSURE RELIEF VALVE. IF LP SERVICE VALVE WAS CLOSED WITH LIQUID PROPANE IN THE LINE TO THE GENERATOR WHEN THE GENERATOR WAS NOT OPERATING.

September 10, 1986

United States

HOLIDAY RAMBLER CORP.

INADEQUATE FASTENING OF THE BRACKETS TO THE FRAME RAIL FOR HOLDING THE HYDRAULIC BRAKE AND GAS RETURN LINES MAY ALLOW FLEXING AND POSSIBLE CHAFING OF THE LINE. CONSEQUENCE OF DEFECT: LINES COULD WEAR THROUGH AND RUPTURE RESULTING IN (1) LEAKAGE OF GASOLINE WHICH IS A FIRE HAZARD AND/OR (2) LOSS OF HYDRAULIC FLUID…

March 4, 1986

United States

HOLIDAY RAMBLER CORP.

MOTOR HOMES WERE BUILT WITH CLEAR PLASTIC LENSES AND BULBS IN THE FRONT TURN SIGNALS INSTEAD OF AMBER COLORED, WHICH IS IN NONCOMPLIANCE WITH FMVSS 108-LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. CONSEQUENCE OF DEFECT: AMBER COLOR SIGNALS INDICATE A WARNING TO OTHER MOTORISTS, HOWEVER A CLEAR/WHITE SIGNAL MAY…

February 13, 1985

United States

HOLIDAY RAMBLER CORP.

SEAM LEAKS MAY DEVELOP IN THE 70 GALLON ALUMINUM FUEL TANK, ALLOWING GASOLINE TO SPILL ON THE GROUND. THIS IS DUE TO POOR SEAM WELDING.