Holidayramblercorp

September 18, 1998

United States

HOLIDAY RAMBLER CORP.

VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH AQUA-HOT HEATING SYSTEMS, MODEL 431-3 ZONE WITH ENGINE LOOP. FIBERGLASS INSULATING MATERIAL LOCATED UNDER THE BURNER HEAD ON THE FLOOR OF THE HEATER ENCLOSURE, CAN BECOME SOAKED WITH FLUIDS (ETHYLENE GLYCOL AND/OR DIESEL FUEL).

April 9, 1998

United States

HOLIDAY RAMBLER CORP.

VEHICLE DESCRIPTION: DIESEL MOTOR HOMES BUILT ON A FREIGHTLINER CHASSIS. THE FUEL RELAY WAS POSITIONED TOO CLOSE TO THE ENGINE.

October 29, 1997

United States

HOLIDAY RAMBLER CORP.

VEHICLE DESCRIPTION: TRAVEL TRAILERS. THE SPRINGS USED ON THE TWO AXLES ARE UNDER RATED.

June 2, 1997

United States

HOLIDAY RAMBLER CORP.

THE "O" RINGS OF THE REGULATOR ASSEMBLY IN THE ONAN EMERALD AND MARQUIS BRAND GENERATOR SETS CAN WEAKEN AND BREAK WHEN EXPOSED TO HIGH AMBIENT TEMPERATURES.

November 5, 1996

United States

HOLIDAY RAMBLER CORP.

A MOUNTING BRACKET FOR THE OPTIONAL HWH JACK CAN RUB AGAINST THE FUEL TANK WHEN THE VEHICLE IS IN MOTION.

April 22, 1996

United States

HOLIDAY RAMBLER CORP.

THE FUSE FOR THE DAYTIME RUNNING LIGHT CIRCUIT MAY BE UNDER RATED FOR THESE MOTORHOMES. THE CIRCUIT REQUIRES A 20 AMP FUSE AND A 15 AMP FUSE MAY HAVE BEEN INSTALLED.

March 15, 1996

United States

HOLIDAY RAMBLER CORP.

THE AWNING ATTACHED FOR THE SLIDE-OUT ROOM CAN UNFURL OR UNROLL DURING TRANSIT CAUSING THE BRACKET TO RIP FREE OF THE SIDEWALL.

November 30, 1995

United States

HOLIDAY RAMBLER CORP.

THE FEDERAL CERTIFICATION LABEL OVERSTATES THE GROSS AXLE WEIGHT RATING (GAWR) AS 5,000 LBS. THE CORRECT GAWR IS 4,670 LBS.

November 8, 1995

United States

HOLIDAY RAMBLER CORP.

THE WRONG SAFETY BELT BUCKLE ENDS WERE USED WHICH COULD CAUSE THE BELT NOT TO RELEASE.

October 13, 1995

United States

HOLIDAY RAMBLER CORP.

WHEN OPERATED AT A HIGH SPEED, THE FRONT WIPER ARM CONNECTION TO THE WIPER DRIVE PIVOT SHAFT CAN LOOSEN CAUSING THE WINDSHIELD WIPER SYSTEM TO FAIL. United States

HOLIDAY RAMBLER CORP.

WHEN OPERATED AT A HIGH SPEED, THE FRONT WIPER ARM CONNECTION TO THE WIPER DRIVE PIVOT SHAFT CAN LOOSEN CAUSING THE WINDSHIELD WIPER SYSTEM TO FAIL.

August 30, 1995

United States

HOLIDAY RAMBLER CORP.

THE FEDERAL CERTIFICATION LABEL INCORRECTLY STATES THE GROSS AXLE WEIGHT RATING (GAWR) CAUSING THE LOAD RATINGS FOR THE TIRES AND TIRE PRESSURES TO BE WRONG. THIS DOES NOT COMPLY WITH FMVSS NO.

August 16, 1995

United States

HOLIDAY RAMBLER CORP.

THE STORAGE COMPARTMENT AT THE REAR OF THE UNIT DOES NOT HAVE A SPECIFIED STORAGE WEIGHT LIMITATION AND CAN THEREFORE BE LOADED BEYOND THE MANUFACTURER'S INTENTIONS. ALSO SOME UNITS WERE DESIGNED WITH A FRESH WATER TANK LOCATED AT THE REAR OF THE UNIT.

August 9, 1995

United States

HOLIDAY RAMBLER CORP.

THE FEDERAL CERTIFICATION LABEL INCORRECTLY STATES THE GROSS AXLE WEIGHT RATING (GAWR) CAUSING THE LOAD RATINGS FOR THE TIRES AND TIRE PRESSURES TO BE WRONG. THIS DOES NOT COMPLY WITH FMVSS NO.

June 20, 1995

United States

HOLIDAY RAMBLER CORP.

TWO LATCHES MOUNTED ON EACH SIDE OF THE REAR ENGINE ACCESS COVER AND SECURE THE COVER WHEN THE MOTORHOME IS IN TRANSIT WERE NOT POSITIONED CORRECTLY.

December 29, 1994

United States

HOLIDAY RAMBLER CORP.

THE REMOTE POWER SWITCH(ES) LOCATED ON THE HYDRAULIC MOTOR THAT OPERATES THE SLIDE-OUT ROOM IS NOT WATER-PROOF ALLOWING MOISTURE TO PENETRATE INTO THE SWITCH CREATING AN ELECTRICAL PATH. United States

HOLIDAY RAMBLER CORP.

THE 12 VOLT BUSS BAR AND TERMINAL CONNECTOR LUG POST WERE INSTALLED WITHOUT A PROTECTIVE COVER. THESE COMPONENTS ARE SUSCEPTIBLE TO POTENTIAL SHORTING UPON CONTACT BY ANY TYPE OF METAL FOREIGN OBJECT.

August 12, 1994

United States

HOLIDAY RAMBLER CORP.

A FUSE WAS OMITTED IN THE SOLAR PANEL CIRCUIT BETWEEN THE RV BATTERY AND THE SOLAR PANEL.

June 10, 1994

United States

HOLIDAY RAMBLER CORP.

AN INCOMPLETE SEAL AT THE REAR OF THE MOTORHOME BETWEEN THE LIVING FACILITY AREA AND THE COMPARTMENT WHICH CONTAINS THE HEATING SYSTEM CAN ALLOW CARBON MONOXIDE (CO) TO ENTER THE LIVING AREA.

March 11, 1994

United States

HOLIDAY RAMBLER CORP.

HIGH TEMPERATURES PRODUCED BY THE GENERATOR EXHAUST PIPE CAN RESULT IN HEAT DISTORTION AND SUBSEQUENT RUPTURE OF THE AIR LINES. A RUPTURE WOULD CAUSE A MALFUNCTION OF THE INSTRUMENT PANEL AIR PRESSURE GAUGES AND/OR ENGAGEMENT OF THE MANUAL PARKING/EMERGENCY BRAKE.