Gulfstreamcoach

August 15, 2008

United States

Gulf Stream Coach, Inc.

GULF STREAM IS RECALLING 50 MY 2008-2009 CRESCENDO, YELLOWSTONE, AND TOURMASTER RECREATIONAL VEHICLES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD. United States

Gulf Stream Coach, Inc.

GULF STREAM IS RECALLING 38 MY 2005, 2008 AND 2009 FRIENDSHIP, SCENIC CRUISER, AND TOURMASTER RECREATIONAL VEHICLES EQUIPPED WITH ZF MODEL 8018 STEERING GEARS. THESE STEERING GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. United States

Gulf Stream Coach, Inc.

GULF STREAM IS RECALLING 5 MY 2008-2008 TOURMASTER RECREATIONAL VEHICLES EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. United States

Gulf Stream Coach, Inc.

GULF STREAM IS RECALLING 26,847 MY 2003-2006 RECREATIONAL VEHICLES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE.

August 5, 2008

United States

Gulf Stream Coach, Inc.

GULF STREAM IS RECALLING 413 MY 1999-2002 SUN VOYAGER, SCENIC CRUISE, FRIENDSHIP, AND TOUR MASTER MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

July 31, 2008

United States

Gulf Stream Coach, Inc.

GULF STREAM IS RECALLING 68 MY 2007-2008 CRESCENDO, TOUR MASTER AND YELLOWSTONE MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS. THE AAC FRONT AXLE STEERING ARM BOLTS WITH A LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER-TIGHTENED WHICH MAY RESULT IN FATIGUE OR FRACTURE OF THE STEERING ARM BOLTS.

November 8, 2007

United States

Gulf Stream Coach, Inc.

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.

March 20, 2007

United States

Gulf Stream Coach, Inc.

CERTAIN MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

November 30, 2006

United States

Gulf Stream Coach, Inc.

ON CERTAIN TRAVEL AND FIFTH WHEEL TRAILERS, THE FUEL STATION MAY BE INSTALLED IN SUCH A MANNER AS TO LIMIT THE AMOUNT OF TRANSVERSE AND/OR LATERAL SUPPORT FOR THE FUEL TANK.

May 23, 2006

United States

Gulf Stream Coach, Inc.

ON CERTAIN CLASS A MOTOR HOMES BUILT ON A SPARTAN CHASSIS, THE STEERING GEAR SUPPORT BRACKET HAS THE POTENTIAL TO FAIL WHEN SUBJECT TO THE REPETITIVE FORCES OF STATIC STEERING CONDITIONS.

April 11, 2006

United States

Gulf Stream Coach, Inc.

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 101 "CONTROLS AND DISPLAYS" AND 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS.

October 4, 2005

United States

Gulf Stream Coach, Inc.

ON CERTAIN CLASS B MOTOR HOMES BUILT ON THE SPRINTER CHASSIS, THE STEEL BRACKET SECURING THE HOLDING TANK IS INSTALLED IN A LOCATION IN WHICH IT PRESSES AGAINST THE OEM BRAKE LINES.

June 2, 2005

United States

Gulf Stream Coach, Inc.

ON CERTAIN MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES. THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

August 3, 2004

United States

Gulf Stream Coach, Inc.

ON CERTAIN MOTOR HOMES BUILT WITH DEWALT/POWER GEAR HYDRAULIC HOSES USED FOR THE SLIDE-OUT ROOMS AND LEVELING JACKS, THE CRIMPING PROCESS FOR ATTACHING THE HOSE FITTING TO THE END OF THE HYDRAULIC HOSE WAS PERFORMED IMPROPERLY.

December 12, 2003

United States

Gulf Stream Coach, Inc.

ON CERTAIN TRAVEL TRAILERS AND FIFTH WHEELS EQUIPPED WITH EZ-FLO GROUND FAULT CIRCUIT INTERRUPTER (GFCI) RECEPTACLES, THE RECEPTACLE MAY NOT TRIP WHEN A GROUND FAULT IS PRESENT.

October 27, 2003

United States

Gulf Stream Coach, Inc.

ON CERTAIN TRAVEL TRAILERS AND FIFTH WHEELS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE.

September 3, 2003

United States

Gulf Stream Coach, Inc.

ON CERTAIN MOTOR HOMES EQUIPPED WITH T-1 THERMAL CIRCUIT BREAKERS, SURFACE MOUNT AND PANEL MOUNT, IF THE CIRCUIT BREAKER HANDLE IS HELD IN THE "ON" POSITION AFTER THE UNIT IS TRIPPED AND THE CIRCUIT CONTACTS WELD TOGETHER, HEAT MAY BE GENERATED THAT MAY DAMAGE ATTACHED OR ADJACENT WIRING CREATING A RISK OF FIRE. United States

Gulf Stream Coach, Inc.

ON CERTAIN MOTOR HOMES BUILT ON THE WORKHORSE W22 CHASSIS, THE DROP DOWN BRACKETS USED TO ATTACH THE HITCH TO THE FRAME RAIL EXTENSIONS MAY NOT BE ADEQUATE.

March 12, 2003

United States

Gulf Stream Coach, Inc.

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS.

May 3, 2002

United States

Gulf Stream Coach, Inc.

ON CERTAIN MOTOR HOME CHASSIS, THE WELDS WHERE THE LIQUID PROPANE (LP) GAS TANK BRACKETING JOINS THE FLOOR TRUSSES MAY NOT BE ADEQUATE.