Freightlinerllc

November 3, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE BRAKE PEDAL PUSH ROD THAT ACTIVATES THE SERVICE BRAKES COULD FRACTURE.

October 4, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: STEP VAN CHASSIS. A HOSE WAS USED IN THE POWER STEERING SYSTEM THAT IS NOT COMPATIBLE WITH POWER STEERING FLUID. United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. A SUPPORT CLAMP WAS OMITTED FROM THE FRONT AXLE HYDRAULIC BRAKE LINE FROM THE CHASSIS TO THE BRAKE.

October 2, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: CERTAIN FIRE TRUCKS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES.

September 22, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: SHUTTLE BUSES, RECREATIONAL VEHICLES, UTILITY VANS, AND HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR WABCO PHASE 1, D-VERSION ANTILOCK BRAKE SYSTEM (ABS), FAIL TO COMPLY TO THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS.

September 5, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: CHASSIS BUILT WITH CATERPILLAR ENGINES AND EQUIPPED WITH FELSTED ELECTRONIC ACCELERATOR PEDALS. THE RETURN SPRINGS CAN BREAK ON THE ACCELERATOR PEDALS THAT ARE EQUIPPED WITH STAINLESS STEEL OR ELECTROPLATED MUSIC WIRE RETURN SPRINGS.

August 29, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: RECREATIONAL VEHICLE CHASSIS. THE COMPONENTS THAT RETAIN THE REAR AXLE WHEEL COVERS MAY HAVE BEEN DAMAGED DURING INSTALLATION. United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: RECREATIONAL VEHICLE CHASSIS. INTERFERENCE CAN OCCUR BETWEEN THE STEER AXLE SLACK ADJUSTERS AND THE AXLE KNUCKLE POST DURING A FULL WHEEL CUT WITH THE BRAKES APPLIED.

August 23, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE UPPER STEERING COLUMN PINCH BOLT MAY NOT HAVE BEEN PROPERLY TORQUED.

August 17, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, SHUTTLE BUSES, TRANSIT BUSES AND STEP VANS EQUIPPED WITH ALLISON 1000 OR 2400 SERIES TRANSMISSIONS. THESE TRANSMISSIONS CAN EXPERIENCE PARK PAWL TO REAR COVER INTERFERENCE DUE TO AN OUT OF FLATNESS CONDITION.

August 7, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH ARVINMERITOR MFS-8 SERIES FRONT AXLE ASSEMBLIES. THE WHEEL BEARING NUT ADJUSTMENT ASSEMBLY MAY 1) RESTRICT A COMPLETE LUBRICATION FILL AT ASSEMBLY AND/OR 2) SHEAR THE SPINDLE PERFORATED WASHER'S LOCKING TAB (LOCATED IN THE INSIDE DIAMETER OF THE WASHER) WHEN… United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT…

July 10, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH ACCURIDE 22. 5 X 8.

June 30, 2000

United States

FREIGHTLINER LLC

CERTAIN SCHOOL BUSES WITH WELDON TECHNOLOGIES' 5050-1400 SURFACE MOUNT MARKER LIGHTS HAVE AN OPTION TO REPLACE EACH OF THE TWELVE CLEARANCE/MARKER/IDENTIFICATION LIGHTS WITH FOUR-CANDLEPOWER LIGHTS, TWICE THE CANDLEPOWER NORMALLY USED. THE HIGHER CURRENT DEMAND CREATED BY THESE LIGHTS CAN CAUSE EXCESSIVE HEAT THROUGH…

May 30, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH EATON AUTOSHIFT GEN II TRANSMISSION ASSEMBLIES. DUE TO A SOFTWARE PROBLEM IN THE TRANSMISSION ASSEMBLIES, THE TRANSMISSION WILL SELECT THE WRONG GEAR.

May 22, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY TRUCKS BUILT WITH AIR BRAKES THAT DID NOT HAVE AIR GAUGES INSTALLED. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: CERTAIN TRACTORS FAIL TO COMPLY WITH FMVSS NO. 121, "AIR BRAKE SYSTEMS.

April 7, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: CONVENTIONAL HEAVY DUTY TRUCKS. THE TIE ROD CROSS TUBES COULD FRACTURE DUE TO FATIGUE CAUSED BY A SYSTEM RESONANCE.

March 17, 2000

United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CERTAIN 12 VOLT POWER OUTLETS. AN UNPLUGGED HOLE IN THE FLOORBOARD CAN ALLOW ROAD SALTS AND MOISTURE INTO AN AREA WHERE A 12 VOLT POWER OUTLET IS MOUNTED. United States

FREIGHTLINER LLC

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS BUILT WITH DUAL LEAF SPRING TYPE AIR RIDE SUSPENSIONS AND VEHICLES BUILT WITH SINGLE LEAF SPRING TYPE AIR RIDE SUSPENSIONS. REAR SUSPENSION SPRINGS CAN FRACTURE THROUGH THE CENTER BOLT HOLE AFTER VEHICLE ASSEMBLY.