Ford

September 13, 2004

United States

Ford Motor Company

CERTAIN MINIVANS MAY HAVE BEEN PRODUCED WITH FRONT WHEEL HUB ASSEMBLIES THAT WERE NOT HEAT TREATED CORRECTLY. THIS CONDITION MAY LEAD TO THE DEVELOPMENT OF SMALL CRACKS IN THE HUB. United States

Ford Motor Company

ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING… United States

Ford Motor Company

ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT. United States

Ford Motor Company

ON CERTAIN TRUCKS EQUIPPED WITH 4. 2L, 4. United States

Ford Motor Company

ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.

August 30, 2004

United States

Ford Motor Company

ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.

July 15, 2004

United States

Ford Motor Company

ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN…

July 14, 2004

United States

Ford Motor Company

ON CERTAIN PICKUP TRUCKS, THE FRAME MAY HAVE A CENTER RAIL SECTION FLANGE THAT WAS NOT FORMED PROPERLY.

July 8, 2004

United States

Ford Motor Company

CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER ADJUSTABLE SEATS MAY HAVE BEEN INADEQUATELY WELDED.

July 7, 2004

United States

Ford Motor Company

CERTAIN POLICE, COMMERCIAL, AND PASSENGER VEHICLES SOLD TO FLEETS TYPICALLY INPUT HIGHER LOADS INTO THE VEHICLE CHASSIS OVERLOADING THE WHEEL BEARINGS AND AXLES. United States

Ford Motor Company

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 6. 0L DIESEL ENGINES, THE ENGINE GROUND STUD THAT ATTACHES THE NEGATIVE BATTERY TERMINAL EYELET TO THE ENGINE BLOCK MAY BE LOOSE.

May 17, 2004

United States

Ford Motor Company

CERTAIN LARIAT AND KING RANCH MODEL PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.

May 13, 2004

United States

Ford Motor Company

CERTAIN VANS AND WAGONS FAIL TO CONFORM TO THE REQUIREMENTS OF PART 567, "CERTIFICATION. " FOR CERTAIN 2003 E250 VANS BUILT WITH LT225/75R16E TIRES, THE REAR AXLE RATING IS INCORRECTLY LISTED ON THE LABEL.

April 26, 2004

United States

Ford Motor Company

CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY…

April 6, 2004

United States

Ford Motor Company

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3. 0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.

March 2, 2004

United States

Ford Motor Company

CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. United States

Ford Motor Company

ON CERTAIN VEHICLES, THE AIR FILTER PAPER IN THESE VEHICLES CAN SMOLDER OR BURN.

December 5, 2003

United States

Ford Motor Company

ON CERTAIN SPORT UTILITY VEHICLES, A POST WITHIN THE SAFETY BELT BUCKLE COVERS COULD FRACTURE, WHICH COULD AFFECT LATCH FUNCTION, RESULTING IN EITHER A "NO LATCH" OR "PARTIAL LATCH" CONDITION. IN THE "PARTIAL LATCH" CONDITION, THE BUCKLE TONGUE CAN BE INSERTED INTO THE BUCKLE AND APPEAR TO BE ENGAGED, BUT WILL…

November 19, 2003

United States

Ford Motor Company

ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.

November 6, 2003

United States

Ford Motor Company

ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.