Westernstartrucks

December 7, 1993

United States

WESTERN STAR TRUCKS, INC.

THE CAB ACCESS GRAB HANDLES HAVE THINNER THAN SPECIFIED WALL THICKNESS AND ARE SUSCEPTIBLE TO FATIGUE FAILURE BREAKING AT THE BEND RADIUS NEAR THE UPPER MOUNTING BOLT HOLE.

July 13, 1993

United States

WESTERN STAR TRUCKS, INC.

THE BURN RATE FOR THE MATTRESS TICKING EXCEEDS THE 4 INCHES PER MINUTE REQUIREMENT OF FMVSS 302, "FLAMMABILITY OF INTERIOR MATERIALS.

October 8, 1992

United States

WESTERN STAR TRUCKS, INC.

PREMATURE FAILURE OF THE ALUMINUM CLUTCH RELEASE LEVER CAN OCCUR FROM STRESS CORROSION DUE TO CONTINUOUS LOADING OF THE LEVER AND EXPOSURE TO ROAD SALT SPRAY.

December 6, 1990

United States

WESTERN STAR TRUCKS, INC.

WHEN BRAKE AIR LINES AND BATTERY ELECTRICAL CABLES ARE ROUTED THROUGH THE ANGLE BRACKETS ON THE FRAME RAILS, THE LEAF SPRING MAY RUB AGAINST THE BATTERY CABLES OR AIR LINES, CAUSING FRAYING AND EVENTUALLY RUPTURE.

December 22, 1989

United States

WESTERN STAR TRUCKS, INC.

THROTTLE RETURN SPRINGS MAY FAIL DURING NORMAL OPERATION WITHOUT PRIOR WARNING.

October 4, 1989

United States

WESTERN STAR TRUCKS, INC.

SEAT BELTS DESIGNED FOR USE ON DRIVER'S SEATS WERE INSTALLED ON PASSENGER SEATS; THIS CAUSES THE STRAP CONNECTING THE BUCKLE TO THE FLOOR TO BE TWISTED.

January 3, 1989

United States

WESTERN STAR TRUCKS, INC.

CABLES USED FOR THROTTLE CONTROL ARE SUBJECT TO FAILING IN SERVICE DUE TO VIBRATIONAL FATIGUE BETWEEN THE CABLE END SLEEVE AND HUB.

August 4, 1988

United States

WESTERN STAR TRUCKS, INC.

STEERING ARMS USED ON FRONT AXLES CONTAIN DIMENSIONAL INCONSISTENCIES.

July 12, 1988

United States

WESTERN STAR TRUCKS, INC.

THE OUTER STAINLESS STEEL SKIN ON THE MUFFLER COULD REACH TEMPERATURES OVER 400 DEGREES.

February 26, 1988

United States

WESTERN STAR TRUCKS, INC.

THROTTLE RETURN SPRINGS MAY FAIL DURING NORMAL OPERATION WITHOUT PRIOR WARNING.

January 18, 1988

United States

WESTERN STAR TRUCKS, INC.

THE C SHAPED CLUTCH RELEASE LEVER MAY HAVE BEEN WEAKENED DUE TO CASTING IMPERFECTIONS.

January 11, 1987

United States

WESTERN STAR TRUCKS, INC.

ALUMINUM FUEL TANK PICKUP TUBE WELDS COULD CRACK AND ALLOW AIR TO BE DRAWN INTO THE FUEL PUMP.

February 4, 1986

United States

WESTERN STAR TRUCKS, INC.

THE ENGINE CONTINUES TO RUN OR CAN START UP WHEN THE SENTINEL SHUTDOWN UNIT BLOCKS THE FLOW OF FUEL. THIS ALLOWS FUEL PRESSURE TO BUILD UP IN THE FUEL LINE WHICH MAY CAUSE THE FUEL LINE OR FILTER TO SPLIT OPEN AND LEAK OR SPRAY FUEL INTO THE ENGINE COMPARTMENT.

August 26, 1985

United States

WESTERN STAR TRUCKS, INC.

THE LAP BELT MAY DISENGAGE FROM THE RETRACTOR ASSEMBLY WHEN IT IS SUBJECTED TO SEVERE LOADS, SUCH AS A FRONTAL ACCIDENT, DUE TO INTERFERENCE BY TWO SEAT FRAME BOLTS. CONSEQUENCE OF DEFECT: SEAT BELT FAILURE DURING AN ACCIDENT CAUSES THE OCCUPANT TO BE UNRESTRAINED WHICH COULD RESULT IN A SEVERE OR FATAL INJURY.

December 5, 1984

United States

WESTERN STAR TRUCKS, INC.

A DEFECTIVE TOGGLE SWITCH MAY HAVE BEEN INSTALLED IN THE SLEEPER OF SOME TRUCKS. THE PROBLEM MAY CAUSE AN INTERMITTENT SHORT CIRCUIT, RESULTING FROM CONSTANT VIBRATION OF THE VEHICLE WHICH MAY CAUSE THE SWITCH TERMINAL TO WEAR THROUGH THE INSULATING MATERIAL.

October 16, 1984

United States

WESTERN STAR TRUCKS, INC.

THE TRAILER STOP LAMP WIRE WAS MISTAKENLY OMITTED FROM AN INSTALLATION DIAGRAM AND MAY NOT BE CONNECTED TO ITS TERMINAL. THIS DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. United States

WESTERN STAR TRUCKS, INC.

SOME DOOR LATCHES MAY NOT BE SECURE DUE TO DEFECTIVE SPRINGS. THE SPRINGS MAY DETACH FROM THE LATCH AT ANY TIME.

January 8, 1984

United States

WESTERN STAR TRUCKS, INC.

THE RATIO ADAPTER ATTACHED TO THE SPEEDOMETER AND AN AIR SWITCH, BOTH LOCATED BEHIND THE DASH, MAY COME IN CONTACT WITH A HEATER DUCT HOSE THAT IS REINFORCED WITH COILED WIRE.