Toyota

March 5, 2003

United States

Toyota Motor Engineering & Manufacturing

ON CERTAIN PASSENGER VEHICLES, THE FUEL TANK CHECK VALVE, LOCATED IN THE FUEL TANK INLET PIPE, MAY BECOME SEPARATED FROM THE INLET PIPE AND FALL INTO THE FUEL TANK. IF THE CHECK VALVE FALLS INTO THE TANK, FUEL MAY SPILL FROM THE FUEL INLET PIPE WHEN THE FUEL PUMP AUTOMATICALLY SHUTS OFF DURING FUELING.

February 11, 2003

United States

Toyota Motor Engineering & Manufacturing

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION. " THE INCORRECT GROSS VEHICLE WEIGHT RATING (GVWR) DATA WAS PRINTED ON THE CERTIFICATION REGULATION LABEL.

December 17, 2002

United States

Toyota Motor Corporation

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND…

October 1, 2002

United States

Toyota Motor Engineering & Manufacturing

ON CERTAIN PASSENGER VEHICLES, IF THE VEHICLE IS DRIVEN UNDER REPEATED START AND STOP OPERATION IN LOW AMBIENT TEMPERATURES AND IN DEEP SNOW, THERE IS A POSSIBILITY THAT SNOW COULD ACCUMULATE IN LARGE QUANTITIES INSIDE THE REAR WHEEL AND FREEZE. THE SNOW FROZEN INSIDE THE WHEEL COULD CONTACT THE REAR BRAKE LINE…

July 30, 2002

United States

Toyota Motor Engineering & Manufacturing

ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION.

May 1, 2002

United States

Toyota Motor Corporation

ON CERTAIN 4X2 VEHICLES EQUIPPED WITH AN ALLOY WHEEL TIRE UPGRADE (OPTIONS WM4, WM8, ZL1-ZL4, DH4, OR DH5) INSTALLED BY THE PROCESSING CENTERS IN JACKSONVILLE, FLORIDA OR COMMERCE, GEORGIA, A LABEL IDENTIFYING THE SPARE TIRE AS A TEMPORARY USE SPARE TIRE WAS NOT INSTALLED. THE UPGRADE INCLUDES 4 LARGER SIZE TIRES…

March 11, 2002

United States

Toyota Motor Engineering & Manufacturing

ON PASSENGER VEHICLES WITH VEHICLE IDENTIFICATION NUMBERS (VIN) STARTING WITH 1NX ONLY AND BUILT FROM JANUARY 8 THROUGH FEBRUARY 13, 2002, IT IS POSSIBLE FOR THE BOLTS THAT JOIN THE REAR BRAKE AND HUB ASSEMBLY TO THE REAR AXLE CARRIER TO BE LOOSE DUE TO INSUFFICIENT TIGHTENING DURING THE ASSEMBLY PROCESS.

January 18, 2002

United States

Toyota Motor Engineering & Manufacturing

ON CERTAIN 2-WHEEL-DRIVE (2WD) AND 4-WHEEL-DRIVE (4WD) 4RUNNER SPORT UTILITY VEHICLES, A COMBINATION OF HEAVY LOADING (SIMULTANEOUS LOADING TO REAR GROSS AXLE WEIGHT RATING AND GROSS VEHICLE WEIGHT RATING) AND SEVERE STEERING MANEUVERS COULD CAUSE THE 2WD 4RUNNER TO LOSE DIRECTIONAL STABILITY.

December 11, 2001

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A THREE-SPOKE STYLE STEERING WHEEL. DURING AIR BAG DEPLOYMENT, IT IS POSSIBLE THAT THE BOTTOM SEAM OF THE FRONT DRIVER'S SIDE AIR BAG MODULE COVER (HORN PAD) COULD BE TORN AWAY ALLOWING THE BOTTOM PORTION OF THE COVER TO COMPLETELY DETACH FROM THE AIR BAG MODULE. United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LEFT FRONT BRAKE TUBE MAY HAVE BEEN DEFORMED PRIOR TO VEHICLE DELIVERY DUE TO IMPROPER INSTALLATION OF A COIL SPRING SPACER THAT WAS INSTALLED TO PREVENT DAMAGE TO THE VEHICLE DURING TRANSPORTATION.

October 10, 2001

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION. DUE TO A UNIQUE COMBINATION OF CONDITIONS WHICH CONSIST OF COLD AMBIENT TEMPERATURES, LOAD APPLIED FROM AIR CONDITIONER AND OTHER ELECTRICAL DEVICES, AND IMMEDIATELY AFTER STARTING THE ENGINE, THERE IS A POSSIBILITY THAT THE VACUUM IN…

October 1, 2001

United States

Toyota Motor Corporation

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CONTINENTAL TOURING TIRES, P205-65R15 92S, INSTALLED AT THE PORTS IN JACKSONVILLE, FLORIDA. THE INCORRECT TIRES WERE INSTALLED ON VEHICLES THAT HAD DAMAGED TIRES.

September 25, 2001

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: PASSENGER VEHICLES. INCOMPLETE DEPLOYMENT OF THE FRONT PASSENGER SIDE AIR BAG COULD OCCUR IN THE EVENT OF A CRASH.

July 5, 2001

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR.

June 7, 2001

United States

Toyota Motor Corporation

VEHICLE DESCRIPTION: 4X2 TRUCKS EQUIPPED WITH TU4 WHITE LETTER TIRE UPGRADE OPTION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. TIRE DAMAGE MAY HAVE OCCURRED DUE TO IMPROPER INSTALLATION, WHICH COULD CAUSE THE TIRE TO DEFLATE OR A BULGE…

March 5, 2001

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT SUB FRAME ASSEMBLY HAS NOT BEEN ADEQUATELY WELDED.

January 16, 2001

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL AND V6 ENGINES, AND BUILT AT ONE OF TWO LINES AT THE KENTUCKY PLANT. THE ACCELERATOR CABLE HOUSING COULD BE DEFORMED AT THE CRUISE CONTROL ACTUATOR-TO-THROTTLE BODY CONNECTION.

September 21, 2000

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: PASSENGER VEHICLES. INSUFFICIENT ELECTRICAL CONTACT CAN OCCUR IN THE TORQUE SENSOR THAT CONTROLS THE POWER ASSIST OPERATION OF THE ELECTRIC POWER STEERING GEAR BOX.

September 7, 2000

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, IOWA, KANSAS, MAINE, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. CONDENSED MOISTURE FROM THE…

August 9, 2000

United States

Toyota Motor Engineering & Manufacturing

VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. THE FRONT DISC BRAKE ROTOR, WHEN EQUIPPED WITH STEEL WHEELS, CAN DEVELOP STRESS FRACTURES IF THE LUG NUTS ARE TIGHTENED WITH EXCESSIVE TORQUE.