Newmarcorporation

January 11, 2008

United States

Newmar Corporation

CERTAIN MOTOR HOME CHASSIS BUILT ON FREIGHTLINER VCL OR XC CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF…

October 17, 2007

United States

Newmar Corporation

CERTAIN DIESEL BUS MOTOR HOMES EQUIPPED WITH DRIVER SEATS BUILT BY VILLA INTERNATIONAL FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS.

August 10, 2007

United States

Newmar Corporation

ON CERTAIN MOTOR HOMES BUILT ON SPARTAN CHASSIS, THE STEERING GEAR ASSEMBLY CONTAINS A SPACER WITH INCORRECT DIMENSIONS. A SPACER OF INSUFFICIENT HEIGHT ALLOWS FOR EXCESSIVE PLAY IN THE RETURN FUNCTION OF THE RECIRCULATION BALLS AND, AS A CONSEQUENCE, THERE IS A FAILURE IN THE CIRCULATORY FUNCTION OF THESE BALLS.

August 8, 2007

United States

Newmar Corporation

ON CERTAIN MOTOR HOMES BUILT ON SPARTAN MM CHASSIS WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

March 5, 2007

United States

Newmar Corporation

CERTAIN CLASS A AND DIESEL PUSHER MOTOR HOMES AND FIFTH WHEEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

November 15, 2006

United States

Newmar Corporation

ON CERTAIN MOTOR HOMES EQUIPPED WITH BUSMAN BOXES, THE BUSMAN BOX LOCATION IS FACE-UP ON THE FLOOR OF ITS COMPARTMENT.

July 26, 2006

United States

Newmar Corporation

CERTAIN CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED. United States

Newmar Corporation

ON CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH DEXTER AXLES, THE DISC BRAKE CALIPER MOUNTING BOLTS MAY STRIP. INSUFFICIENT CLAMP LOAD BETWEEN CALIPER AND YOKE CAN CAUSE THE CALIPER TO DISASSEMBLE AND ADVERSELY AFFECT THE TRAILERS BRAKING SYSTEM.

July 24, 2006

United States

Newmar Corporation

CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH 8000 LB. TANDEM AXLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.

June 19, 2006

United States

Newmar Corporation

ON CERTAIN MOTOR HOMES EQUIPPED WITH SPARTAN STEERING COLUMNS, THE STEERING COLUMN HAS AN INCORRECT BUSHING THAT DOES NOT PROPERLY LIMIT THE TRAVEL OF THE STEERING COLUMN. United States

Newmar Corporation

ON CERTAIN MOTOR HOMES BUILT ON SPARTAN K2 AND MM CHASSIS, THE STEERING GEAR SUPPORT BRACKET HAS THE POTENTIAL TO FAIL WHEN SUBJECT TO THE REPETITIVE FORCES OF STATIC STEERING CONDITIONS.

September 8, 2005

United States

Newmar Corporation

ON CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH TREDIT WHEELS, THE RIMS MAY HAVE POOR WELD QUALITY AND INSUFFICIENT PRESS FIT BETWEEN THE WHEEL RIM AND DISC.

July 25, 2005

United States

Newmar Corporation

ON CERTAIN MOTOR HOMES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH I-SHAFTS SUPPLIED BY ZF HEAVY DUTY STEERING, THERE IS A POTENTIAL FOR A FAILURE OF THE FORK/SHAFT CONNECTION. AT THE NON-WELDED SIDE OF THE I-SHAFT THERE IS A UNIVERSAL JOINT.

June 2, 2005

United States

Newmar Corporation

ON CERTAIN MOTOR HOMES EQUIPPED WITH AMETEK NGI GAUGES, THE AIR GAUGES ARE NOT PROPERLY CALIBRATED AND THE LOW AIR WARNING INDICATOR MAY BE ACTIVATED WHEN ACTUAL AIR RESERVOIR PRESSURE READINGS ARE BELOW THE FEDERAL MOTOR VEHICLE SAFETY STANDARD REQUIRED RANGE OF 60 TO 65PSI.

April 25, 2005

United States

Newmar Corporation

ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH ARE EQUIPPED WITH WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

March 24, 2005

United States

Newmar Corporation

CERTAIN CLASS A MOTOR HOMES BUILT ON WORKHORSE CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 101, "CONTROLS AND DISPLAY" AND STANDARD NO.

September 17, 2004

United States

Newmar Corporation

ON CERTAIN FIFTH WHEEL RECREATIONAL VEHICLES, DURING THE MODEL YEAR CHANGE, TWO POSITIONS IN THE VEHICLE IDENTIFICATION NUMBER (VIN) WERE NOT CORRECTLY CHANGED TO INDICATE A NEW MODEL YEAR. THEREFORE, THE VIN TAG ILLUSTRATES AN INCORRECT VIN NUMBER.

August 17, 2004

United States

Newmar Corporation

ON CERTAIN MOTOR HOMES, DURING MANUFACTURING, THE SEAT BELT SHOULDER HARNESS ATTACHMENT LOCATION FOR THE PASSENGER SEAT WAS NOT PROPERLY WELDED OR ATTACHED.

May 18, 2004

United States

Newmar Corporation

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES.

February 5, 2004

United States

Newmar Corporation

CERTAIN MOTORHOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS," AND NO.