Hyundai

May 3, 2004

United States

Hyundai Motor America

DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST ON CERTAIN PASSENGER VEHICLES, FUEL SPILLAGE OCCURRED AS A RESULT OF FUEL TANK DAMAGE CAUSED BY CONTACT BETWEEN A VAPOR TUBE HOSE CLAMP EAR AND THE FUEL TANK. THE VAPOR TUBE HOSE CLAMP EAR WAS FOUND TO BE MISPOSITIONED AND…

April 9, 2004

United States

Hyundai Motor America

SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.

March 16, 2004

United States

Hyundai Motor America

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3. 5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC…

December 18, 2003

United States

Hyundai Motor America

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.

December 3, 2003

United States

HYUNDAI CARIBBEAN-PUERTO RICO

ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.

November 4, 2003

United States

Hyundai Translead

ON CERTAIN TRAILERS EQUIPPED WITH BENDIX EC-30T ELECTRONIC CONTROL UNITS (ECU). IF THE TRAILER-MOUNTED ABS WARNING LAMP CIRCUIT EXPERIENCES AN ELECTRICAL SHORT AND THE SHORT IS NOT REPAIRED, THE HIGH SIDE POWER SWITCH INSIDE THE ECU THAT CONTROLS THE ILLUMINATION OF THE TRAILER-MOUNTED ABS WARNING LAMP MAY EVENTUALLY…

August 26, 2003

United States

Hyundai Motor America

ON CERTAIN VEHICLES, IF THE FRONT PASSENGER SEAT IS UNOCCUPIED OR IS OCCUPIED BY SOMEONE LIGHTER THAN 56. 4 POUNDS, THE PASSENGER AIR BAG IS DEACTIVATED AND WILL NOT DEPLOY IF A CRASH OCCURS. United States

Hyundai Motor America

ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT PASSENGER AIR BAG IS MOUNTED BENEATH THE RIGHT PORTION OF THE INSTRUMENT PANEL'S PADDED SURFACE. TEAR LINES ARE FORMED INTO THE UNDERSIDE OF THE INSTRUMENT PANEL'S PADDED SURFACE DURING THE PRODUCTION PROCESS OF THE INSTRUMENT PANEL TOP PAD.

August 5, 2003

United States

HYUNDAI CARIBBEAN-PUERTO RICO

ON CERTAIN SPORT UTILITY VEHICLES, THE DRIVER SEAT BELT BUCKLE WIRING COULD BE DAMAGED BY INTERFERENCE WITH THE DRIVER SEAT CUSHION HEIGHT ADJUSTER MECHANISM. DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP TO ILLUMINATE.

July 22, 2003

United States

Hyundai Motor America

ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER.

March 17, 2003

United States

Hyundai Motor America

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A TRACTION CONTROL SYSTEM (TCS), IF THE T125/70D-15 COMPACT SPARE TIRE IS INSTALLED ON A FRONT WHEEL POSITION, THE TCS MAY INADVERTENTLY ACTIVATE BEGINNING AT SPEEDS OF 20 MPH.

January 2, 2003

United States

Hyundai Motor America

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 2. 7 LITER V-6 ENGINES, IMPROPERLY MANUFACTURED CRANKSHAFT POSITION SENSORS (CPS) WERE INSTALLED.

December 20, 2002

United States

Hyundai Motor America

ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE…

November 21, 2002

United States

HYUNDAI TRUCK SERVICE

ON CERTAIN CAB-OVER CLASS 4 TRUCKS, THE SNAP-IN TIRE VALVE STEMS IN THE WHEELS OF THESE TRUCKS CAN LEAK AIR.

November 5, 2002

United States

Hyundai Motor America

ON CERTAIN PASSENGER VEHICLES, THE DRIVER SEAT BELT BUCKLE WIRING COULD BE DAMAGED BY INTERFERENCE WITH THE DRIVER SEAT CUSHION HEIGHT ADJUSTER MECHANISM.

June 25, 2002

United States

Hyundai Motor America

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT.

May 24, 2002

United States

Hyundai Motor America

ON CERTAIN PASSENGER VEHICLES, THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) SIDE IMPACT AIR BAG SATELLITE SENSORS MAY BE TOO SENSITIVE TO SOME LATERAL ACCELERATIONS THAT ARE NOT CAUSED BY SIDE IMPACTS TO THE VEHICLE, SUCH AS FORCEFULLY SLAMMING A DOOR CLOSED.

April 11, 2002

United States

HYUNDAI CARIBBEAN-PUERTO RICO

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 2. 7 LITER V-6 ENGINES, IMPROPERLY MANUFACTURED CRANKSHAFT POSITION SENSORS (CPS) WERE INSTALLED.

April 9, 2002

United States

Hyundai Motor America

ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY.…

February 8, 2002

United States

Hyundai Motor America

ON CERTAIN PASSENGER VEHICLES, THE LEFT LOWER INSTRUMENT PANEL BRACKET WAS NOT INSTALLED.