Harleydavidson

December 8, 2003

United States

Harley-Davidson Motor Company

CERTAIN MOTORCYCLES WITH CARBURETED ENGINES WHICH HAVE AN ANGLED FUEL FITTING ON THE GAS TANK DO NOT MEET HARLEY-DAVIDSON IMPACT TEST STANDARDS.

February 21, 2003

United States

Harley-Davidson Motor Company

ON CERTAIN MOTORCYCLES, THE MIRROR STEM COULD FRACTURE ALLOWING THE MIRROR TO FALL.

January 24, 2003

United States

Harley-Davidson Motor Company

ON CERTAIN MOTORCYCLES, THE REAR BRAKE LINE ASSEMBLIES COULD FRACTURE INTERNALLY.

October 3, 2002

United States

Harley-Davidson Motor Company

ON CERTAIN MOTORCYCLES, THE BRAIDED CLUTCH CABLE COULD CONTACT THE REAR BRAKE LINE AND CAUSE THE BRAKE LINE TO ABRADE OVER TIME, RESULTING IN A LOSS OF REAR BRAKE FLUID.

January 4, 2002

United States

Harley-Davidson Motor Company

ON CERTAIN MOTORCYCLES, THE CLIPS THAT RETAIN THE WIRING FOR THE FRONT FENDER TIP LIGHT CAN BECOME DETACHED FROM THE FENDER, CAUSING THE WIRES TO FRAY AND SHORT.

September 20, 2001

United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH A FUEL HOSE THAT COULD COME OFF THE CARBURETOR.

May 1, 2001

United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH A BRAKE SYSTEM THAT COULD CONTAIN OUT OF SPECIFICATION BRAKE FLUID.

March 28, 2001

United States

Harley-Davidson Motor Company

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY.

October 28, 1999

United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE FUEL TANK VENT SYSTEM CAN MALFUNCTION. United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE BANK SENSOR ANGLE SYSTEM CAN MALFUNCTION. United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE HANDLE BARS ON THESE MOTORCYCLES CAN BREAK.

July 23, 1999

United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THESE SIDECARS WERE BUILT WITH AN AXLE THAT COULD BREAK. United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH A FUEL TANK VENT FITTING THAT COULD BE PLUGGED ALLOWING THE CARBURETOR TO OVERFLOW FUEL.

June 14, 1999

United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE OWNER MANUAL DOES NOT CONTAIN THE PROPER OWNER NOTIFICATION AS SPECIFIED IN 49 CFR PART 575. United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE MANUAL CHOKE LEVER IS NOT LABELED IN CONFORMANCE WITH REQUIREMENTS OF FMVSS NO. United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE BRAKE FLUID RESERVOIR IS NOT LABELED IN CONFORMANCE WITH REQUIREMENTS OF FMVSS NO. United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE CERTIFICATION LABEL WAS OMITTED.

January 13, 1999

United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE ENGINE CAM BOLT CAN LOSE ITS CLAMP LOAD AND/OR BREAK.

October 23, 1998

United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: MOTORCYCLES. THE CERTIFICATION LABEL INCORRECTLY INDICATES THE FRONT TIRE SIZE AS 100/90-19 57H INSTEAD OF THE CORRET DESIGNATION MH90-21 56H.

July 14, 1998

United States

Harley-Davidson Motor Company

VEHICLE DESCRIPTION: FL TOURING MOTORCYCLES. A LOSS OF ELECTRICAL POWER THROUGH THE IGNITION SWITCH CAN OCCUR DUE TO EXCESSIVE CURRENT AND OTHER FACTORS.