Gilligllc

February 24, 2023

United States

Gillig, LLC

GILLIG, LLC (GILLIG) is recalling certain 2011-2022 Low Floor 29-foot CNG, diesel hybrid, and electric transit buses. The rear suspension lower control arm may fail.

February 10, 2023

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2022-2023 Low Floor transit and shuttle buses. Incompatible steering system draglink parts may have been installed during the vehicle assembly process, potentially resulting in long-term damage of the steering system.

October 24, 2022

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2022 Low Floor transit buses. The steering shaft grease fitting may contact and damage the protective shroud.

July 28, 2022

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor vehicles equipped with Cummins BP74E battery packs. The battery packs may develop a coolant leak internally, causing the battery pack to short circuit.

June 17, 2022

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor electric transit buses. The EV resolver cable connector may experience a loss of electrical connectivity, unexpectedly switching from Drive to Neutral with no warning.

April 25, 2022

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position.

September 10, 2021

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2020-2021 Low Floor Battery Electric vehicles equipped with Cummins Electric Drivetrain Systems. When a system shutdown occurs, the high voltage shutdown override switch may not function, with no warning to the driver.

July 23, 2021

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2020-2021 Low Floor vehicles equipped with Cummins L9 Diesel Engines that have remote Stage 2 fuel filters and pressurized hoses. A fuel leak may occur from the fuel hose between the fuel pump and the remote fuel filter head.

July 15, 2021

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2020-2021 Low Floor vehicles equipped with Cummins L9 Diesel Engines. The engine calibration software's management of the injection of Diesel Exhaust Fluid can allow excessive ammonia into the tailpipe exhaust.

June 28, 2021

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2020-2021 Low Floor Diesel, CNG, and Battery Electric buses. The rear axle may come out of alignment during operation.

May 14, 2021

United States

Gillig, LLC

Gillig, LLC. (Gillig) is recalling certain 2017-2020 Low Floor vehicles.

April 23, 2021

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2020-2021 29, 35, 40-foot Low Floor and BRT buses powered by Compressed Natural Gas (CNG). The overlap between the curb side and street side roof doors is insufficient and may allow the street side door to accidentally open.

July 2, 2020

United States

Gillig, LLC

Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to provide power steering assist.

June 10, 2020

United States

Gillig, LLC

Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor buses. The rear suspension lower control rods may experience fatigue failure due to stiffened end bushings.

April 29, 2020

United States

Gillig, LLC

Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor transit buses powered by compressed natural gas (CNG). The thermally activated pressure relief device (PRD) installed on the CNG fuel system may not vent the system when exposed to heat, potentially resulting in the system rupturing.

March 25, 2020

United States

Gillig, LLC

Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.

June 14, 2019

United States

Gillig, LLC

Gillig LLC (Gillig) is recalling certain 2018-2019 Low Floor vehicles equipped with a certain batch of glass roof hatches. Temperature and vibration stresses may cause the tempered glass roof hatch to shatter.

March 8, 2019

United States

Gillig, LLC

Gillig LLC (Gillig) is recalling certain 2014-2019 Low Floor buses. Uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights.

January 28, 2019

United States

Gillig, LLC

Gillig LLC (Gillig) is recalling certain 2016-2018 Low Floor buses. The ball stud of the steering system draglink may not have been properly tightened.

December 12, 2018

United States

Gillig, LLC

Gillig, LLC (Gillig) is recalling certain 2016-2017 Gillig Low Floor transit buses. As built, one of the emergency exit windows may not be able to be easily used in the event of an emergency.