General

November 19, 1985

United States

General Motors, LLC

THE FUEL FEED AND FUEL RETURN PIPE ASSEMBLIES INCLUDES A HOSE WHICH MAY CONTACT THE POINTED END OF THE RADIATOR SHROUD ATTACHING SCREW. THIS COULD CAUSE A GASOLINE LEAK.

November 18, 1985

United States

General Motors, LLC

INCORRECT TAIL LAMP LENS WERE INSTALLED, LENS DO NOT CONFORM TO FMVSS 108, LAMP REFLECTIVE DEVICE AND ASSOCIATED EQUIPMENT. CONSEQUENCE OF DEFECT: IN TIMES OF REDUCED VISIBILITY, AN APPROACHING VEHICLE MAY NOT BE AWARE OF THIS VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.

October 23, 1985

United States

General Motors, LLC

CLUTCH CABLE IS NOT PROPERLY SECURED CAUSING THE CABLE TO CONTACT THE MASTER CYLINDER BRAKE PIPE. CONSEQUENCE OF DEFECT: OVER A PERIOD OF TIME THIS MAY CAUSE WEAR THROUGH, BRAKE FLUID LEAK AND PARTIAL LOSS OF BRAKING ACTION WHICH COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.

October 15, 1985

United States

General Motors, LLC

THE FAN BLADE, WHEN SUBJECTED TO HIGH STRESS LEVELS, CAN FATIGUE AND BREAK APART AT THE HUB WHILE THE ENGINE IS RUNNING. CONSEQUENCE OF DEFECT: IF BREAKAGE OCCURS WHILE HOOD IS OPEN, A PERSON WORKING UNDER THE HOOD OR NEAR THE TRUCK COULD BE STRUCK BY A BLADE PART AND BE INJURED.

October 7, 1985

United States

General Motors, LLC

THE REAR BRAKE RELEASE TIME MAY BE GREATER THAN THE TIME SPECIFIED IN FMVSS 121, "AIR BRAKE SYSTEM". IN ADDITION, SOME TRACTORS MAY HAVE WARPED PARKING BRAKE APPLY SPRINGS WHICH ALSO EFFECT THE REAR BRAKE RELEASE TIME.

October 4, 1985

United States

General Motors, LLC

THE GENERATOR "BAT" TERMINAL LOCATED ON THE RECTIFIER END FRAME MAY CONTACT THE CARBURETOR FUEL INLET PIPE. CONSEQUENCE OF DEFECT: THE "BAT" STUD MAY RUB THROUGH THE TERMINAL BOOT AND CONTACT THE FUEL PIPE WHICH COULD RESULT IN AN UNDERHOOD FIRE AND CAUSE BURN INJURIES TO THE OCCUPANT.

October 1, 1985

United States

General Motors, LLC

CARS MAY LOSE THE WIRE SNAP RINGS THAT HOLD THE DIFFERENTIAL CROSS SHAFT IN POSITION IN THE REAR AXLE DIFFERENTIAL CASE ASSEMBLY, ALLOWING THE SHAFT TO MOVE. CONSEQUENCE OF DEFECT: THE CROSS SHAFT MOVEMENT COULD CAUSE THE SHAFT TO CONTACT THE CARRIER OR PINION TEETH, POSSIBLY LOCKING UP THE REAR WHEELS AND RESULT IN…

September 19, 1985

United States

General Motors, LLC

THE CERTIFICATION LABEL LOCATED ON THE LEFT FRONT DOOR DID NOT INCLUDE A REQUIRED FEDERAL CERTIFICATION STATEMENT. CONSEQUENCE OF DEFECT: VEHICLES DO NOT COMPLY WITH FEDERAL REGULATION 567.

September 11, 1985

United States

General Motors, LLC

THE FUEL RETURN HOSE BETWEEN THE SWITCHING VALVE AND THE FUEL TANK SENDING UNITS MAY BE INCORRECTLY CONNECTED. CONSEQUENCE OF DEFECT: FUEL SUPPLIED BY ONE TANK IS RETURNED TO THE OTHER TANK WHICH COULD OVERFILL AND LEAK.

August 14, 1985

United States

General Motors, LLC

SOME WAGONS WERE ASSEMBLED WITH A JA2 REAR SYSTEM INSTEAD OF THE JA3 BRAKE SYSTEM. THESE STATION WAGONS MAY EXCEED THE MAXIMUM STOPPING DISTANCE REQUIRED BY FMVSS 105.

July 2, 1985

United States

General Motors, LLC

THE FRONT AIR BRAKE HOSE MAY CONTACT THE INNER FENDER ON THE LEFT AND/OR RIGHT SIDES OF SOME TRUCKS. IN SOME INSTANCES, THE BRAKE HOSE MAY RUB THROUGH, RESULTING IN A LOSS OF AIR PRESSURE UPON BRAKE APPLICATION.

June 10, 1985

United States

General Motors, LLC

THE CAB ENTRY STEP MOUNTING STRAP MAY FAIL IN THE AREA OF THE STEP SUPPORT BRACKET TO STRAP WELD INTERFACE. CONSEQUENCE OF DEFECT: IF THE STEP MOUNTING STRAP FAILS WHILE A PERSON IS ATTEMPTING TO ENTER OR EXIT THE CAB, PERSONAL INJURY COULD RESULT.

May 1, 1985

United States

General Motors, LLC

RIM INFORMATION MAY HAVE BEEN OMITTED ON CERTIFICATION LABEL INSTALLED ON THE LEFT FRONT DOOR. CONSEQUENCE OF DEFECT: THESE TRUCKS DO NOT CONFORM WITH FMVSS 120, TIRE SELECTIONS AND RIMS FOR VEHICLES OTHER THAN PASSENGER CARS.

April 29, 1985

United States

General Motors, LLC

THE REAR BUMPER MAY FRACTURE DURING A REAR END COLLISION, PUNCTURE THE FUEL TANK, AND CAUSE A FUEL LEAK. CONSEQUENCE OF DEFECT: A FUEL LEAK CREATES THE POTENTIAL FOR A FIRE WHICH COULD RESULT IN BURN INJURIES TO PERSONS IN OR NEAR THE CAR. United States

General Motors, LLC

EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT.

April 26, 1985

United States

General Motors, LLC

A LOSS OF BONDING ADHESION BETWEEN THE PAINT AND THE WINDSHIELD OPENING AREA COULD ALLOW THE WINDSHIELD TO SEPARATE DURING A 30 MILE PER HOUR FRONTAL BARRIER TEST REQUIRED BY FMVSS 212, WINDSHIELD RETENTION. CONSEQUENCE OF DEFECT: WINDSHIELD SEPARATION DURING AN ACCIDENT COULD RESULT IN AN UNBELTED OCCUPANT BEING…

April 12, 1985

United States

General Motors, LLC

THE ENGINE AIR CLEANER PLASTIC TRIM COVER COULD DETACH FROM THE AIR CLEANER ASSEMBLY AND FALL FORWARD ON THE EXHAUST MANIFOLD. CONSEQUENCE OF DEFECT: IF THE CAR IS BEING OPERATED AT THE TIME OF DETACHMENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR WITHOUT WARNING.

March 29, 1985

United States

General Motors, LLC

THE FUEL SYSTEM MAY LEAK AT THE THROTTLE BODY INJECTION FUEL FEED PIPE CONNECTION. CONSEQUENCE OF DEFECT: THIS LEAKAGE COULD RESULT IN AN UNDERHOOD FIRE WHICH COULD SPREAD TO THE PASSENGER COMPARTMENT AND CAUSE BURN INJURIES TO OCCUPANTS.

March 19, 1985

United States

General Motors, LLC

THE CRUISE CONTROL VACUUM SOLENOID VALVES MAY MALFUNCTION AT ANY TIME THE ENGINE IS RUNNING AND THE CRUISE CONTROL IS ENGAGED AND CAUSE UNEXPECTED ENGINE ACCELERATION. CONSEQUENCE OF DEFECT: LOSS OF ACCELERATOR CONTROL COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. United States

General Motors, LLC

THE TIRE PLACARD LABEL ON THE LEFT FRONT DOOR MAY HAVE BEEN PRINTED WITH AN ERROR WHICH SPECIFIES A HIGHER MAXIMUM LOADING THAN IS ALLOWED. CONSEQUENCE OF DEFECT: EXCESSIVE VEHICLE LOADING COULD CAUSE A TIRE BLOWOUT AND RESULT IN AN ACCIDENT.