Freightlinerllc

June 17, 2003

United States

FREIGHTLINER LLC

ON CERTAIN TRUCK TRACTORS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.

June 2, 2003

United States

FREIGHTLINER LLC

ON CERTAIN THOMAS SCHOOL BUSES, THE ALTERNATOR CABLE CAN PINCH BETWEEN THE AIR CONDITIONING COMPRESSOR AND ENGINE BLOCK.

May 29, 2003

United States

FREIGHTLINER LLC

ON CERTAIN HEAVY TRUCKS AND MOTORHOMES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.

May 1, 2003

United States

FREIGHTLINER LLC

CERTAIN TRUCKS DO NOT COMPLY WITH SEVERAL FEDERAL STANDARDS: (1) THE VEHICLE CERTIFICATION LABELS, PART 567, "CERTIFICATION;" (2) TIRE LABELS, FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 120, "IRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS;" (3) INCOMPLETE VEHICLE DOCUMENT, PART 568… United States

FREIGHTLINER LLC

ON CERTAIN TRUCKS WITH AIR BRAKES, THE AIR MANAGEMENT UNIT INTRODUCED WITH M2 TRUCKS INCLUDES A PRESSURE SWITCH ASSEMBLY (PSA) MODULE FOR THE LOW AIR PRESSURE INDICATOR AND STOP LAMP CONTROL FUNCTIONS. THE PSA MODULE COVER ALLOWS WATER INGRESSION THAT COULD CAUSE THE STOP LAMP SWITCH TO SHORT "ON.

March 21, 2003

United States

FREIGHTLINER LLC

ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.

March 13, 2003

United States

FREIGHTLINER LLC

ON CERTAIN FIRE TRUCKS EQUIPPED WITH HARRISON HYDRA-GEN GENERATOR PUMPS, THE TUBING CONNECTING THE SOFT START TO THE GENERATOR PUMP CAN BREAK AWAY FROM THE FITTING AND SPRAY HYDRAULIC FLUID ONTO THE EXHAUST.

December 17, 2002

United States

FREIGHTLINER LLC

ON CERTAIN TRUCK-TRACTOR MODEL VEHICLES EQUIPPED WITH CONMET SIMPLEX STATIONARY OR SLIDING FIFTH-WHEEL, THE CLINCH PINS THAT RETAIN THE FIFTH-WHEEL PIVOT PINS MAY NOT BE FULLY INSTALLED.

December 13, 2002

United States

FREIGHTLINER LLC

ON CERTAIN HEAVY TRUCKS, THE CAST OUTPUT YOKE ON THE MERCEDES-BENZ TRANSMISSIONS COULD FRACTURE ON VEHICLE WITH 1610 OR 16T SERIES DRIVELINES.

December 3, 2002

United States

FREIGHTLINER LLC

ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR 3126E HYDRAULICALLY CONTROLLED ELECTRONICALLY ACTUATED UNIT INJECTED DIESEL ENGINES WITH HIGH EFFICIENCY PUMPS (HEP8), THE PUMP COMPONENTS MAY EXPERIENCE A HIGH PRESSURE SEAL FAILURE WHICH CAN RESULT IN A SHORT PERIOD OF ROUGH RUNNING AND SUBSEQUENT ENGINE STALL DUE TO A…

December 2, 2002

United States

FREIGHTLINER LLC

ON CERTAIN SCHOOL AND TRANSIT BUSES EQUIPPED WITH REYCO REAR AXLE AIR SUSPENSIONS, DEFLATED SUSPENSION AIR BAGS COULD CREATE EXCESSIVE DRIVELINE ANGLES CAUSING U-JOINT DAMAGE. United States

FREIGHTLINER LLC

ON CERTAIN TRUCKS EQUIPPED WITH MANIFOLD DASH VALVES WITH PUSH TO CONNECT FITTINGS USED TO CONTROL THE PARK BRAKE FUNCTION ON TRUCKS AND TRAILERS WITH AIR BRAKES, THE PARK KNOB CAN POP OUT UNEXPECTEDLY WHILE THE VEHICLE IS IN MOTION. THIS WILL EXHAUST THE AIR FROM THE PARK BRAKE SYSTEM ON THE TRAILER AND APPLY THE…

October 31, 2002

United States

FREIGHTLINER LLC

ON CERTAIN SCHOOL OR TRANSIT BUSES WITH PASSENGER SEAT BELTS WITH RETRACTORS, THE COVER HALVES FOR THE RETRACTABLE PORTION OF THE BELT CAN SEPARATE COMPLETELY AND RELEASE THE SEAT BELT CONNECTOR. IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT…

October 17, 2002

United States

FREIGHTLINER LLC

ON CERTAIN CREW CAB TRUCKS EQUIPPED WITH HYDRAULIC BRAKES, THE HYDRAULIC BRAKE LINES FROM THE CHASSIS MOUNTED ANTI-LOCK BRAKE SYSTEM (ABS) MODULATOR VALVE CAN BE DAMAGED BY INTERFERENCE WITH THE CAB MOUNTED AUXILIARY HEATER DUCT.

September 16, 2002

United States

FREIGHTLINER LLC

ON CERTAIN SCHOOL BUS CHASSIS WITH CUMMINS ISB ENGINES WITH MECHANICAL THROTTLE, THE THROTTLE CABLE CAN VIBRATE EXCESSIVELY AND BREAK NEAR THE END FITTING THAT ATTACHES TO THE ENGINE LINKAGE.

April 10, 2002

United States

FREIGHTLINER LLC

ON CERTAIN TRUCKS EQUIPPED WITH MERITOR BRAND 12" X 4" DCM DRUM PARKING BRAKE, THE BOLTS USED TO ATTACH THE PARKING BRAKE ASSEMBLY TO THE FLANGE YOKE ARE TOO LARGE AND CAN INTERFERE WITH THE PROPER ENGAGEMENT OF THE BRAKING SYSTEM AND POSSIBLY DISENGAGE.

April 2, 2002

United States

FREIGHTLINER LLC

ON CERTAIN SCHOOL BUSES, THE BRAKE HOSES FROM THE CHASSIS TO FRONT BRAKE CHAMBERS COULD DEVELOP LEAKS DUE TO THE HOSE ROUTING THAT COULD OVERSTRESS THE HOSE DURING SHARP TURNS.

March 20, 2002

United States

FREIGHTLINER LLC

ON CERTAIN TRUCKS, A CAPACITOR IN THE POWER LINE CONTROL (PLC) FILTER COULD OVERHEAT AND/OR IGNITE WHEN SUBJECTED TO REVERSE POLARITY ELECTRICAL SPIKES. United States

FREIGHTLINER LLC

ON CERTAIN SCHOOL BUSES, MISALIGNMENT OF THE FAN DRIVE SYSTEM COMPONENTS CAN CAUSE PREMATURE BELT AND PULLEY BEARING WEAR. United States

FREIGHTLINER LLC

CERTAIN HEAVY DUTY TRUCKS CONVERTED FROM SLEEPERCABS TO DAY CABS AND EQUIPPED WITH A DETROIT DIESEL OPTIMIZED IDLE SYSTEM. THE IDLE SYSTEM WAS NOT COMPLETELY DISABLED IN THE CAB CONVERSION PROCESS.