Forestriver

July 28, 2008

United States

Forest River, Inc.

FOREST RIVER IS RECALLING 57 MY 2007-2008 MOTOR HOMES BUILT ON FREIGHTLINER XC CHASSIS AND EQUIPPED WITH SAF-HOLLAND REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

July 7, 2008

United States

Forest River, Inc.

FOREST RIVER IS RECALLING CERTAIN MY 2003-2006 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE.

June 20, 2008

United States

Forest River, Inc.

FOREST RIVER IS RECALLING 1 MY 2001 TSUNAMI CLASS A DIESEL PUSHER MOTOR HOME MOTOR HOMES EQUIPPED WITH A NORCOLD REFRIGERATOR. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

May 12, 2008

United States

Forest River, Inc.

FOREST RIVER IS RECALLING 38 MY 2006-2007 CHARLESTON 400TS, 400QS, 410DST, 410DST-4, 410QS, AND 410QS-4 MOTOR HOMES BUILT ON FREIGHTLINER XC MOTOR HOME CHASSIS. THE CHASSIS CONTAINS STEERING FILTERS THAT CAN PLUG DUE TO FAILURE OF THE SCREEN ADHESION TO THE FILTER HOUSING CAUSING A RISE IN RETURN LINE PRESSURE…

May 6, 2008

United States

Forest River, Inc.

FOREST RIVER IS RECALLING 93 MY 2007-2008 CHARLESTON AND BERKSHIRE MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS. THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER-TIGHTENED.

February 14, 2008

United States

Forest River, Inc.

FOREST RIVER IS RECALLING 89 MY 2003-2008 TSUNAMI MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS. THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER.

December 14, 2007

United States

Forest River, Inc.

ON CERTAIN FIFTH WHEEL TRAILERS, THE GROSS VEHICLE WEIGHT RATING (GVWR) LABEL LOCATED ON THE FRONT OF THE HITCH PIN BOX OF THE UNIT CONTAINS AN IMPROPER LISTING OF THE GVWR.

November 5, 2007

United States

Forest River, Inc.

ON CERTAIN FOLDING CAMPING TRAILERS (FCT) EQUIPPED WITH A POWER WINCH UNIT, MODEL P55000, BUILT BY CAREFREE OF COLORADO, AN INCORRECT MATERIAL WAS USED IN THE MANUFACTURE OF THE CABLE SHAFTS ON SOME OF THESE POWER WINCH UNITS. UNDER CERTAIN CIRCUMSTANCES WHILE THE FOLDING CAMPING TRAILER TOP IS BEING LIFTED, IF THE…

October 16, 2007

United States

Forest River, Inc.

CERTAIN TRAVEL TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION. " THE LABEL LOCATED ON THE LOWER ROADSIDE FRONT OF THE UNIT CONTAINS AN IMPROPER LISTING OF THE TIRE AND RIM.

June 7, 2007

United States

Forest River, Inc.

ON CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH HICKORY SPRINGS "BIG EASY TRIPLE STEPS," AN IMPROPER ENGAGEMENT OF THE BOTTOM STEP PIVOT ARM WITH THE FORMED STOP EDGE OF THE MIDDLE STEP SUPPORT BRACKET CAN RESULT IN THE BOTTOM STEP ROTATING TO AN UNSAFE DOWNWARD ANGLE.

May 8, 2007

United States

Forest River, Inc.

ON CERTAIN FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH SUBURBAN THREE BURNER MATCH LIGHT GAS RANGES, THE OVEN THERMOSTAT CONTROL VALVE CAN ALLOW GAS FLOW TO THE OVEN BURNER WHEN THE OVEN CONTROL KNOB IS PUSHED IN AND NOT FULLY IN THE CORRECT POSITION TO LIGHT THE PILOT.

March 5, 2007

United States

Forest River, Inc.

CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

June 16, 2006

United States

Forest River, Inc.

ON CERTAIN TRAILERS, THE WHEEL STUD CAN FAIL AND SEPARATES AT THE BASE OF THE THREAD. THIS REDUCES CLAMP FORCE ON THE WHEEL.

November 29, 2005

United States

Forest River, Inc.

ON CERTAIN CLASS B MOTOR HOMES, IF THE AXLE BOTTOMS OUT AGAINST THE RUBBER SUSPENSION SNUBBERS, IT IS POSSIBLE THAT THE "U" BOLTS THAT HOLD THE SPRINGS TO THE REAR AXLE CAN PENETRATE THE STEEL TUBE AND COME INTO CONTACT WITH THE STEEL LIQUID PROPANE (LP) MANIFOLD.

October 17, 2005

United States

Forest River, Inc.

ON CERTAIN MOTOR HOMES EQUIPPED WITH TREDIT WHEELS, THE RIMS MAY HAVE POOR WELD QUALITY AND INSUFFICIENT PRESS FIT BETWEEN THE WHEEL RIM AND DISC.

May 19, 2005

United States

Forest River, Inc.

ON CERTAIN MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

March 30, 2005

United States

Forest River, Inc.

ON CERTAIN TRAVEL TRAILERS THAT USE ALUMINUM WHEELS, THE LUG BOLTS AND WHEELS CAN COME OFF.

June 1, 2004

United States

Forest River, Inc.

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES.

September 17, 2003

United States

Forest River, Inc.

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS.

November 7, 2002

United States

Forest River, Inc.

ON CERTAIN CLASS A MOTOR HOMES BUILT ON EITHER A FORD OR WORKHORSE CHASSIS, THE POWER FEED FOR THE FOG LAMPS MAY HAVE BEEN MIS-WIRED.