Featherlitetrailermanufacturingllc

December 13, 2024

United States

Featherlite Trailer Manufacturing, LLC

Featherlite Trailer Manufacturing, LLC (Featherlite) is recalling certain 2023-2024 Living Quarters Horse Trailers, models 7821, 7841, 9807, and 9808. The cooktop may have a rubber gas line instead of a copper line.

May 8, 2012

United States

Featherlite Trailer Manufacturing, LLC

FEATHERLITE IS RECALLING CERTAIN MODEL YEAR 2006-2012 TRAILERS EQUIPPED WITH A MERITOR AXLE. THE BEARING SYSTEM HAS EXHIBITED LOW DURABILITY LIFE IN CERTAIN VEHICLE APPLICATIONS.

March 22, 2012

United States

Featherlite Trailer Manufacturing, LLC

FEATHERLITE IS RECALLING CERTAIN MODEL YEAR 2012 8415 TRAILERS, EQUIPPED WITH ELECTRIC/HYDRAULIC (E/H) BRAKE ACTUATOR PUMPS. SOME OF THESE PUMPS MAY NOT HAVE BEEN PROPERLY HEAT TREATED.

March 1, 2011

United States

Featherlite Trailer Manufacturing, LLC

FEATHERLITE IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2012 FEATHERLITE TRAILERS EQUIPPED WITH ARVINMERITOR AXLES THAT CONTAIN THE FAG BRAND BEARING SYSTEM. THE BEARING SYSTEM HAS EXHIBITED LOW DURABILITY LIFE IN CERTAIN VEHICLE APPLICATIONS.

November 18, 2010

United States

Featherlite Trailer Manufacturing, LLC

FEATHERLITE TRAILERS IS RECALLING CERTAIN TRAILERS EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE.

July 25, 2006

United States

Featherlite Trailer Manufacturing, LLC

ON CERTAIN TRAILERS EQUIPPED WITH DEXTER AXLES, THE DISC BRAKE CALIPER MOUNTING BOLTS MAY STRIP. INSUFFICIENT CLAMP LOAD BETWEEN CALIPER AND YOKE CAN CAUSE THE CALIPER TO DISASSEMBLE AND ADVERSELY AFFECT THE TRAILERS BRAKING SYSTEM.

June 14, 2005

United States

Featherlite Trailer Manufacturing, LLC

ON CERTAIN MOTOR HOMES BUILT ON PREVOST BUS CHASSIS AND EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

May 25, 2004

United States

Featherlite Trailer Manufacturing, LLC

CERTAIN COACHES WERE EQUIPPED WITH SANDY TV LIFTS.

May 18, 2004

United States

Featherlite Trailer Manufacturing, LLC

ON CERTAIN SNOWMOBILE TRAILERS, INADEQUATE WELDS THAT ATTACH THE AXLES TO THE BODY OF THE TRAILER CAN FAIL.

December 5, 2003

United States

Featherlite Trailer Manufacturing, LLC

ON CERTAIN CUSTOM BUILT SPECIALTY TRAILERS EQUIPPED WITH DEXTER AXLES AND CREWSON AUTOMATIC SLACK ADJUSTERS, THE PUSH ROD ARMS ON THE AXLE BRAKES ARE TOO LONG.

November 6, 2003

United States

Featherlite Trailer Manufacturing, LLC

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE.

October 4, 2002

United States

Featherlite Trailer Manufacturing, LLC

ON CERTAIN TRAILERS EQUIPPED WITH SPRING BRAKE CONTROL VALVE ASSEMBLIES. THERE IS A RECESSED AREA ON TOP OF THE VALVE IN WHICH A BRASS GUIDE PIN FITS DOWN INSIDE THE BODY OF THE VALVE AND IS HELD IN PLACE BY A STEEL SNAP RING.

June 17, 2002

United States

Featherlite Trailer Manufacturing, LLC

ON CERTAIN LIVESTOCK AND HORSE STEEL GOOSENECK TRAILERS, INADEQUATE REINFORCEMENT AND MATERIAL ON CERTAIN COMPONENTS OF THE TRAILER'S GOOSENECK ASSEMBLY CAN, OVER TIME, LEAD TO A FAILURE OF THE ASSEMBLY.

March 20, 2001

United States

Featherlite Trailer Manufacturing, LLC

VEHICLE DESCRIPTION: TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS N841, N821, N641, AND N621. THESE REFRIGERATORS CAN EXPERIENCE A COOLING SYSTEM LEAK CAUSED BY OPERATION IN THE AC ELECTRIC MODE.

February 7, 2001

United States

Featherlite Trailer Manufacturing, LLC

VEHICLE DESCRIPTION: RECREATIONAL VEHICLES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.

December 5, 2000

United States

Featherlite Trailer Manufacturing, LLC

VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH DOTSCO COUPLERS AND SAFETY CHAIN/FASTENER ASSEMBLIES. THE COUPLER LOCKING PIN THAT ENSURES THAT THE COUPLER REMAINS LOCKED CAN BE MISPLACED AND NOT INSTALLED BY THE OPERATOR.

September 29, 2000

United States

Featherlite Trailer Manufacturing, LLC

VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH TEKONSHA OR BARGMAN BREAKAWAY SWITCH ASSEMBLIES. THE SUBJECT SWITCHES ARE BASE PARTS 2011 AND 2011P, AND ARE BRANDED TEKONSHA (2011) AND BARGMAN (50-85-009).

September 15, 1998

United States

Featherlite Trailer Manufacturing, LLC

VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH AQUA-HOT HEATING SYSTEMS, MODEL 431-3 ZONE WITH ENGINE LOOP. FIBERGLASS INSULATING MATERIAL LOCATED UNDER THE BURNER HEAD ON THE FLOOR OF THE HEATER ENCLOSURE, CAN BECOME SOAKED WITH FLUIDS (ETHYLENE GLYCOL AND/OR DIESEL FUEL).

December 20, 1995

United States

Featherlite Trailer Manufacturing, LLC

IMPROPER WELD PROCEDURES WERE USED TO ATTACH THE TONGUE CHANNEL TO THE TRAILER FRAME.