Damoncorporation

June 16, 2009

United States

Damon Corporation

DAMON IS RECALLING 2,415 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION.

October 22, 2008

United States

Damon Corporation

DAMON IS RECALLING 43 MY 2006-2009 DAYBREAK AND MY 2009 DAYBREAK SPORT MOTOR HOMES BUILT ON WORKHORSE RECREATIONAL VEHICLE CHASSIS. THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM MAY HAVE BEEN IMPROPERLY TORQUED DURING ASSEMBLY.

October 9, 2008

United States

Damon Corporation

DAMON IS RECALLING 4,677 MY 2004-2006 CHALLENGER, DAYBREAK, INTRUDER, MY 2004-2005 ESCAPER, ULTRASPORT, AND MY 2005 ASTORIA AND ASTORIA WALDORF MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE.

August 7, 2008

United States

Damon Corporation

DAMON IS RECALLING 179 MY 2008 ASTORIA, TUSCANY,ESSENCE, AND MY 2008-2009 ASTORIA PACIFIC MOTOR HOME CHASSIS EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

July 2, 2008

United States

Damon Corporation

DAMON IS RECALLING 804 MY 1999 INTRUDER, ULTRASPORT, AND ESCAPER MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

June 5, 2008

United States

Damon Corporation

DAMON IS RECALLING 265 MY 2007 INTRUDER (373, 374, 378), MY 2007-2009 OUTLAW (3611), AND MY 2009 CHALLENGER (371, 376, 377, 378) MOTOR HOMES BUILT ON FORD CHASSIS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN…

May 22, 2008

United States

Damon Corporation

DAMON IS RECALLING 738 MY 2005-2007 ASTORIA, TUSCANY, MY 2005 ASTORIA WALDORF, AND MY 2006-2007 ASTORIA PACIFIC MOTOR HOMES BUILT ON FREIGHTLINER XC CHASSIS. THE CHASSIS CONTAINS STEERING FILTERS THAT CAN PLUG DUE TO FAILURE OF THE SCREEN ADHESION TO THE FILTER HOUSING CAUSING A RISE IN RETURN LINE PRESSURE…

February 5, 2008

United States

Damon Corporation

DAMON IS RECALLING 126 MY 2007-2008 TUSCANY, MY 2008 ASTORIA, AND ASTORIA PACIFIC MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS. THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER-TIGHTENED.

January 11, 2008

United States

Damon Corporation

ON CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING.

March 20, 2007

United States

Damon Corporation

CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

January 30, 2007

United States

Damon Corporation

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

November 28, 2006

United States

Damon Corporation

ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8. 1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER.

September 12, 2006

United States

Damon Corporation

ON CERTAIN CLASS A MOTOR HOMES, SOME HYDRAULIC LINES FOR THE LEVELING JACK SYSTEM MAY BE IMPROPERLY SECURED OR ROUTED TOO CLOSE TO A DRIVE TRAIN HEAT SOURCE.

June 30, 2006

United States

Damon Corporation

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.

April 24, 2006

United States

Damon Corporation

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, "CONTROLS AND DISPLAYS" AND NO.

August 17, 2005

United States

Damon Corporation

SOME (PACIFIC/WALDORF EDITION) MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.. 120 "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.

March 21, 2003

United States

Damon Corporation

DURING THE WINTERIZATION PROCESS ON CERTAIN MOTOR HOMES FROM NOVEMBER 5, 2002 THROUGH JANUARY 6, 2003, THE RV ANTIFREEZE USED MAY HAVE BEEN CONTAMINATED WITH ENGINE ANTIFREEZE.

March 5, 2003

United States

Damon Corporation

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS.

October 10, 2002

United States

Damon Corporation

CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM WITH SERIAL NUMBERS BETWEEN 700000 AND 1008700 AND MANUFACTURED BETWEEN DECEMBER 1996 AND FEBRUARY 1999. THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY… United States

Damon Corporation

CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 442, 443, 452, EV452, 453, 462, EV462, 463, EV463, 482, EV482, 483, EV483, 874, AND 875 MANUFACTURED BETWEEN JANUARY 1987 AND MAY 1995. THESE REFRIGERATORS CAN EXPERIENCE A BREAK DOWN IN A RUBBER SEAL WITHIN THE GAS VALVE.